W PERIODIC MAINTENANCE 09 CHASSIS LUBRICATION POINTS 4 month interval or 6 000 mile maximum No Fittings L T n Tie Rods 4 t E Relay Rod 2 2 1 IdlerArrn t 1 A si i Upper ani Joints 2 r wir Lower Ball Ioints 2 i I Lubrication not required on Toronado A water R st resistant E P Chassis Lubricant that meets GM 1 ir specifizmtion 6031 M or equivalent should be used At each engine or change interval all friction and bearing surfaces ir r the linkage for the throttle clutch and R parking brake should be lubricated with engine oil Ball and LIFT PDINTS socket in the throttle linkage should be lubricated with Seal Lubricant No 1050169 or equivalent whenever they are t disassembled I I l i 3 WI EEL BEARING LUBRICANT Drun r brakes wheel bearings should be packed with i chassis lube meeting GM specification 6031 M or I equivalent Disc brake wheel bearings should be packed V t with 1051195 or equivalent l l SPEEDOMETER CRUISE CONTROL CABLE i Zi Lubricate cables every 24 months Apply a coating of l speedometer cable grease such as A C ST640 or A C 1518 or equivalent to tl1e lower two thirds of cable only i i POWER STEERING GEAR AND PUMP I Check lubricant level in pump at each oil change interval Maintain lubricant level with power steering fluid i e No 1050017 or equivalent If adding less than a pint Dexron or equivalent automatic transmission fluid can be used Use only DEXRON or equivalent automatic Gear lubrication is provided by oil supplied by the transmission fluids This fluid has been especially pump formulated and tested for use in automatic transmissions 1 For draining and refilling or checking and adding fluid refer to the specific transmission Section 7 AI R CLEANER All Engines The air cleaner has a disgosable air filter element Soft COOLING SYSTEM plastic nanges on tire element seal tire an cleaner body and The system should be penedncally inspected for leak cover A1l air will pass through the filter element It is designed to use highly inhibited year around Replace air iliter element every 24 months or 24 000 Ethylene Glycol solution or equivalent both summer and miles whichever occurs first under normal conditions and Willtefe more frequently under dusty conditions Do not attempt to E fY 24 m h i he SYSWFH Slwuld he mP Ft lY service the element drained and flushed When refilling use enough year around Ethylene Glyool No 389200 or equivalent Ethylene Glycol coolant labeled as meeting specification MANUAL TRANSIVHSSION GMl899 to insure at least 20 F protection on all except Periodic or seasonal changes of lubricant are not Toronado and 33 F on Toronado On refill of A C or recommended The lubricant level should be cheeked at H D cooling only use Anti foam No 1050531 or each engine oil change interval Use lubricant No 1051066 equivalent or equivalent Always clean dirt from around plug before d Alcohol base coolants or plain water will not provide removing a equate engine cooling The radiator cap should be thoroughly washed every 12 l AUTOMATIC TRANSMISSION months with clean water to remove any foreign matter l Check Fluid level at each engine oil change Change particularly from the valve fluid every 24 months or 24 000 miles whichever occurs Only check when cool Keep coolant level to Fill t first Cold mark on radiator on all except cars with Y 72 option Includes and Toronado On cars with Y 72 option and Toronado Turbo Hydra Matic 350 wash screen coolant level should be checked vinrally at the see through Turbo l Iydra Matic 375 and 400 install new strainer coolant reservoir at each engine oil change while the engine is at normal operating temperature When level drops to Under heavy duty operating conditions or excessive ADD mark at normal operating temperature add one stop and go driving perform the above every 12 000 miles half ethylene glycol and one half water to reservoir not at I