SPECIFICATIONS 9 SECTION 9 STEERING GEAR Mast Jacket Flange to Toe Plate Screws 120 Ib in Steering Ratio Instrument Panel Column Mounting Gear 18 1 Bracket Bolts 20 lb ft Overall 23 5 1 Column Flange to Toe Panel Screws 120 lb in TORQUE CHART Column Upper and Lower Cover Screws 13 lb in Worn Bearing Preload 3 1 2 to 4 1 2 in lbs Turn Signal Switch Mounting Screws Sector Lash Adjustment 8 to 10 in lbs Standard Column 35 lb in Total thru Center High Point Telescoping Column 25 lb in Max Steering Gear Preload 10 lb in Lower Bearing Retaining Screws Steering Gear Mounting Bolts 28 lb ft Telescoping Column 25 lb in Pitman Shaft Nut 95 lb ft Signal Switch Lever Retaining Screw 15 lb in Steering Wheel Nut 35 lb ft Hazard Warning Knob 4 lb in Tie Rod End Nut 35 lb ft Wire Protector Mounting Screws Tie Rod Clamp Bolts 130 lb in Telescoping Column 23 lb in Idler Arm Mounting Bolts 20 lb ft Mast Jacket Upper Flange Mounting Steering Gear Coupling Nut 29 lb ft Bolts Standard Column 23 lb in RECOMMENDED TIRE INFLATION PRESSURES Pounds per Square Inch Cool Standard Inflation Pressure For Models Tire Ply Tire Usage All Loads Including Full Rated Front Rear 1 to 6 Passengers Sgagjagd 200 Lbs Luggage 4 Ply Rat1ng 2 Ply 7 00 13 15 p 1100 Lbs Load 1 to 5 Passengers Monza cou 6 200 Lbs Luggage 4 Ply Rat1ng 2 Ply 7 00 13 15 p 950 Lbs Load Monza 1 to 5 Passengers l Convertible 200 Lbs Luggage 4 Ply Rat1ng 2 Ply 7 00 13 15 950 Lbs Load 1 Tire inflation pressures may increase as much as six 3 Cool tire inflation pressure after vehicle has been 6 pounds per square inch psi when hot inoperative for three 3 hours or more or driven less than one 1 mile Hot tire inflation pressure After 2 For continuous high speed operation over 75 MPH vehicle has been driven ten 10 miles or more at increase tire inflation pressures four 4 pounds per 60 70 MPH Squgre meh Over the mcommendeq pressures up to a 4 Vehicles with luggage racks do not have a load limit maximum of 32 pounds per square inch cool for 4 ply mater than S Qcified rating tires When the 4 psi pressure adjustment for g p sustained high speed with maximum vehicle load 5 When towing trailers the allowable passenger and would require inflation pressures above the maximum cargo load must be reduced by an amount equal to the allowable speed must be limited to 75 miles per hour trailer tongue load on the trailer hitch CORVAIR SHOP MANUAL SUPPLEMENT