SPECIFICATIONS 9 SECTION 9 STEERING GEAR Mast Jacket Flange to Toe Plate Screws 120 lb in Steering Ratio Instrument Panel Column Mounting Gear 18 1 Bracket Bolts 20 lb ft Overall 23 5 1 Column Flange to Toe Panel Screws 120 lb in TORQUE CHART Column Upper and Lower Cover Screws 13 lb in Worn Bearing Preload 3 1 2 to 4 1 2 in lbs Turn Signal Switch Mounting Screws Sector Lash Adjustment 8 to 10 in lbs Standard Column 35 lb in in excess of above Telescoping Column 25 lb in Max Steering Gear Preload 14 lb in Lower Bearing Retaining Screws Steering Gear Mounting Bolts 28 lb ft Telescoping Column 25 lb in Pitman Shaft Nut 95 lb ft Signal Switch Lever Retaining Screw 15 lb in Steering Wheel Nut 35 lb ft Hazard Warning Knob 4 lb in Tie Rod End Nut 35 lb ft Wire Protector Mounting Screws Tie Rod Clamp Bolts 130 lb in Telescoping Column 23 lb in Idler Arm Mounting Bolts 20 lb ft Mast Jacket Upper Flange Mounting Steering Gear Coupling Nut 29 lb ft Bolts Standard Column 23 lb in SECTION IO RECOMMENDED TIRE INFLATION PRESSURES Pounds per Square Inch Cool M d 1 T P1 Standard Inflation Pressure for Optional Inflation Pressure O 6 S ue Y All Loads Including Full Rated for Reduced Loads 1 to 6 Passengers 1 to 5 Passengers 200 lbs Luggage 750 lbs load 1100 lb L d All Models 4 Ply Rating 2 Ply S O3 Front Rear Front Rear 15 30 15 26 1 Tire inflation pressures may increase as much as 3 Cool tire inflation pressure after vehicle has been six 6 pounds per square inch PSI when hot inoperative for three 3 hours or more or driven 2 For continuous high speed operation over 75 MPH less thmxone 1 m11 HO UYQ mflatmn pl ssurez after vehicle has been driven ten 10 miles or increase tire inflation pressures four 4 pounds per more at 60 70 MPH square 1nch over the recommended pressures up to 3 maximum O 32 pounds per Square mch QOOI for 4 Vehicles with luggage racks do not have a load 4 ply ratmg tuqes Or 40 pounds per Square meh for limit rreater than the 1100 load s ecified above 8 ply rating tires Sustained speeds above 75 MPH 5 p are not recommended when the 4 pounds per square 5 When towing trailers the allowable passenger and inch adjustment would require pressures greater cargo load must be reduced by an amount equal to than the maximums stated above the trailer tongue load on the trailer hitch